How do you replace the crankshaft pulley and front Crankshaft Seal in four cylinder engine on Chevrolet Malibu?

In order to replace the crankshaft pulley, the vehicle should be lifted and support on jack stands, and then remove the under vehicular splash shield. Next involves the removal of the drive belt and in the case of the 1.5L engine the drive belt tensioner. Tap or lock the pulley so that it stops then proceed to remove the center bolt of the crankshaft pulley. Check condition of rubber damper segment of the pulley; retain old bolt for use in the initial phase of installation if necessary. To do this use a crankshaft pulley remover or you can also use a standard crankshaft processor puller with the exhaust U-bolts then shift the crankshaft pulley off the crankshaft. If you have max out the above procedures and you needed to replace the crankshaft front oil seal then go to the next step. New pulley apply clean engine oil on the hub, align it with the oil pump rotor and the crankshaft flat and insert it. Replacing a particular bolt by a new one, secure the pulley and again tighten the bolt up to the recommended torque setting. The process of installing is the reverse of removal process and at the last reconnect the battery. For crankshaft front oil seal replace, then you have to remove the crankshaft pulley, to use a seal removal tool to take out the old seal, clean seal bore and check for any damages. Apply clean engine oil on the lip of new seal and screw it into the bore till it sits on the cylinder head timing chain cover with the fully open side directed into the engine. Before fitting the crankshaft pulley make sure that the sealing surface of the crankshaft pulley hub is greased.

Genuine Chevrolet Malibu Crankshaft Seal

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

17 Crankshaft Seals found

View related parts
Chevrolet Malibu Seal Assembly, Crankshaft Rear Oil
Part Number: 12591866
$14.65 MSRP: $36.43
You Save: $21.78 (60%)
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Replaces: 90298408, 90325572, 90280462, 90354378
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2004-2022 Chevrolet Malibu | 4 DOOR HATCHBACK, 4 DOOR HYBRID, 4 DOOR NOTCHBACK, BASE 4 DOOR NOTCHBACK, CLASSIC 4 DOOR NOTCHBACK, LS 4 DOOR HATCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR HATCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR HATCHBACK, LTZ 4 DOOR NOTCHBACK, MAXX SS 4 DOOR HATCHBACK, SS 4 DOOR NOTCHBACK | 4 Cyl 2.0L, 4 Cyl 2.2L, 4 Cyl 2.4L, 4 Cyl 2.5L
View related parts
Chevrolet Malibu Seal, Crankshaft Front Oil
Part Number: 12584041
$8.54 MSRP: $16.12
You Save: $7.58 (48%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Replaces: 12580989, 55564509, 12609467, 90571925
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2016-2019 Chevrolet Malibu | LT HYBRID 4 DOOR NOTCHBACK | 4 Cyl 1.8L
- 2004-2014 Chevrolet Malibu | 4 DOOR HATCHBACK, 4 DOOR HYBRID, 4 DOOR NOTCHBACK, BASE 4 DOOR NOTCHBACK, CLASSIC 4 DOOR NOTCHBACK, LS 4 DOOR HATCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR HATCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR HATCHBACK, LTZ 4 DOOR NOTCHBACK, MAXX SS 4 DOOR HATCHBACK, SS 4 DOOR NOTCHBACK | 4 Cyl 2.2L, 4 Cyl 2.4L
View related parts
Chevrolet Malibu Seal Assembly, Crankshaft Front Oil
Part Number: 12626923
$18.98 MSRP: $31.41
You Save: $12.43 (40%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal; Crankshaft Seal, Front Crank Seal, Front Seal
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2013-2022 Chevrolet Malibu | LS 4 DOOR NOTCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR NOTCHBACK | 4 Cyl 2.0L, 4 Cyl 2.5L
View related parts
Chevrolet Malibu Seal,Crankshaft Front Oil
Part Number: 12661527
$11.67 MSRP: $19.32
You Save: $7.65 (40%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2016-2024 Chevrolet Malibu | L 4 DOOR NOTCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR NOTCHBACK, RS 4 DOOR NOTCHBACK | 4 Cyl 1.5L
View related parts
Chevrolet Malibu Seal,Crankshaft Front Oil
Part Number: 14090906
$20.16 MSRP: $38.03
You Save: $17.87 (47%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Replaces: 12577710
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1997-2010 Chevrolet Malibu | 4 DOOR, 4 DOOR HATCHBACK, 4 DOOR HYBRID, 4 DOOR NOTCHBACK, LS 4 DOOR, LS 4 DOOR HATCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR HATCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR HATCHBACK, LTZ 4 DOOR NOTCHBACK, LX 4 DOOR, MAXX SS 4 DOOR HATCHBACK, SS 4 DOOR NOTCHBACK | 6 Cyl 3.1L, 6 Cyl 3.5L, 6 Cyl 3.5L Flex, 6 Cyl 3.9L
View related parts
Chevrolet Malibu Seal Assembly, Crankshaft Rear Oil
Part Number: 12592195
$41.03 MSRP: $71.41
You Save: $30.38 (43%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL KIT, Engine Rear Main Bearing
- Position: Rear
- Replaces: 14085829
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005-2010 Chevrolet Malibu | 4 DOOR HATCHBACK, 4 DOOR HYBRID, 4 DOOR NOTCHBACK, BASE 4 DOOR NOTCHBACK, LS 4 DOOR HATCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR HATCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR HATCHBACK, LTZ 4 DOOR NOTCHBACK, MAXX SS 4 DOOR HATCHBACK, SS 4 DOOR NOTCHBACK | 6 Cyl 3.5L, 6 Cyl 3.5L Flex, 6 Cyl 3.9L
View related parts
Chevrolet Malibu Seal,Crankshaft Front Oil
Part Number: 12608750
$7.56 MSRP: $11.91
You Save: $4.35 (37%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Replaces: 12592355
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008-2012 Chevrolet Malibu | 4 DOOR HYBRID, LS 4 DOOR NOTCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR NOTCHBACK | 6 Cyl 3.6L
View related parts
Chevrolet Malibu Seal Assembly, Crankshaft Rear Oil
Part Number: 12637710
$41.15 MSRP: $68.12
You Save: $26.97 (40%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal, Rear Main Seal Retainer
- Position: Rear
- Replaces: 12608748, 12620955, 12592243, 12592242
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008-2012 Chevrolet Malibu | 4 DOOR HYBRID, LS 4 DOOR NOTCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR NOTCHBACK | 6 Cyl 3.6L
View related parts
Chevrolet Malibu Seal Unit, Crankshaft Rear (Free Of Asbestos)
Part Number: 10121044
$34.25 MSRP: $53.87
You Save: $19.62 (37%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL KIT, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1982-1983 Chevrolet Malibu | CLASSIC 4 DOOR, CLASSIC STATION WAGON, EL CAMINO, MONTE CARLO | 6 Cyl 3.8L, 8 Cyl 4.4L, 8 Cyl 5.0L
View related parts
Chevrolet Malibu Seal, Crankshaft Rear Oil
Part Number: 12653685
$12.60 MSRP: $19.99
You Save: $7.39 (37%)
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2016-2024 Chevrolet Malibu | L 4 DOOR NOTCHBACK, LS 4 DOOR NOTCHBACK, LT 4 DOOR NOTCHBACK, LTZ 4 DOOR NOTCHBACK, RS 4 DOOR NOTCHBACK | 4 Cyl 1.5L
View related parts
Chevrolet Malibu Seal, Crankshaft Rear Main Bearing Cap *Orange
Part Number: 24500058
$13.05
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1982-1983 Chevrolet Malibu | CLASSIC 4 DOOR, CLASSIC STATION WAGON, EL CAMINO, MONTE CARLO | 6 Cyl 3.8L
View related parts
Chevrolet Malibu Seal,Crankshaft Rear Oil
Part Number: 22545259
$16.67 MSRP: $21.99
You Save: $5.32 (25%)
Ships in 1-2 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1997-1999 Chevrolet Malibu | 4 DOOR, LS 4 DOOR, LX 4 DOOR | 4 Cyl 2.4L
View related parts
Chevrolet Malibu Seal Assembly, Cross Shaft Front Oil
Part Number: 10111769
$2.77 MSRP: $4.35
You Save: $1.58 (37%)
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Replaced by: 10243247
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1982-1983 Chevrolet Malibu | CLASSIC 4 DOOR, CLASSIC STATION WAGON, EL CAMINO, MONTE CARLO | 6 Cyl 3.8L, 8 Cyl 4.4L, 8 Cyl 5.0L
View related parts
Chevrolet Malibu Seal,Crankshaft Rear Oil
Part Number: 55576715
$19.30 MSRP: $30.37
You Save: $11.07 (37%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: SEAL, Engine Rear Main Bearing; Rear Main Seal
- Position: Rear
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2016-2019 Chevrolet Malibu | LT HYBRID 4 DOOR NOTCHBACK | 4 Cyl 1.8L
View related parts
Chevrolet Malibu Seal Assembly, Crankshaft Oil
Part Number: 552711
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1982-1983 Chevrolet Malibu | CLASSIC 4 DOOR, CLASSIC STATION WAGON, EL CAMINO, MONTE CARLO | 6 Cyl 4.3L Diesel, 8 Cyl 5.7L Diesel
View related parts
Chevrolet Malibu Shedder, Crankshaft Oil
Part Number: 1193966
Product Specifications
- Other Name: SHEDDER, Engine Front Cover & Crankshaft Seal
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1982-1983 Chevrolet Malibu | CLASSIC 4 DOOR, CLASSIC STATION WAGON, EL CAMINO, MONTE CARLO | 6 Cyl 3.8L
View related parts
Chevrolet Malibu Seal,Crankshaft Front Oil
Part Number: 22531277
Product Specifications
- Other Name: SEAL, Engine Front Cover & Crankshaft Seal
- Position: Front
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 1997-1999 Chevrolet Malibu | 4 DOOR, LS 4 DOOR, LX 4 DOOR | 4 Cyl 2.4L

Chevrolet Malibu Crankshaft Seal

Chevrolet Malibu Crankshaft Seal is another component which is situated at the front of the engine of the vehicle and its main function is to stop the leakage of oil from the crankcase. Usually made of metal and rubber, this round seal is one of the most important that help to maintain the lubrication of the engine while decreasing the level of friction, which in turn affects the wear of the engine's parts. In the course of the years, there are different types of Crankshaft Seal that may have been fitted to different models of Chevrolet Malibu but, the general role of the Crankshaft Seal will always be the same across the models. Such symptoms may include oil leaks and poor performance of the vehicle, especially in vehicles that have made many miles on the road- which could beCompiled suggest that a change may be due to help crankshaft seal the engine perform as it should.

Each OEM Chevrolet Malibu Crankshaft Seal we offer is competitively priced and comes with the assurance of the manufacturer's warranty for the part. Furthermore, we guarantee the speedy delivery of your orders right to your doorstep. Our hassle-free return policy is also in place for your peace of mind.

Chevrolet Malibu Crankshaft Seal Parts Questions & Experts Answers

Seal Assembly, Crankshaft Front Oil
12626923
Q: How do you replace the crankshaft pulley and front Crankshaft Seal in four cylinder engine on Chevrolet Malibu?
A: In order to replace the crankshaft pulley, the vehicle should be lifted and support on jack stands, and then remove the under vehicular splash shield. Next involves the removal of the drive belt and in the case of the 1.5L engine the drive belt tensioner. Tap or lock the pulley so that it stops then proceed to remove the center bolt of the crankshaft pulley. Check condition of rubber damper segment of the pulley; retain old bolt for use in the initial phase of installation if necessary. To do this use a crankshaft pulley remover or you can also use a standard crankshaft processor puller with the exhaust U-bolts then shift the crankshaft pulley off the crankshaft. If you have max out the above procedures and you needed to replace the crankshaft front oil seal then go to the next step. New pulley apply clean engine oil on the hub, align it with the oil pump rotor and the crankshaft flat and insert it. Replacing a particular bolt by a new one, secure the pulley and again tighten the bolt up to the recommended torque setting. The process of installing is the reverse of removal process and at the last reconnect the battery. For crankshaft front oil seal replace, then you have to remove the crankshaft pulley, to use a seal removal tool to take out the old seal, clean seal bore and check for any damages. Apply clean engine oil on the lip of new seal and screw it into the bore till it sits on the cylinder head timing chain cover with the fully open side directed into the engine. Before fitting the crankshaft pulley make sure that the sealing surface of the crankshaft pulley hub is greased.