What is the importance of determining the nature of a problem with the automatic transaxle before considering repair work on Chevrolet Cobalt,HHR and Saturn ION?

In the event of a problem with the transmission assembly, determine the cause before considering repairs. This requires knowledge of the transmission assembly's operation and access to specialized test equipment. Due to the complexity of diagnosis and repair, this manual does not cover these procedures, therefore refer problems to a qualified repair facility.

How do you remove the transaxle for Chevrolet Cobalt,HHR,Pontiac G5 and Saturn ION?

To remove the transmission assembly, start by placing the vehicle in PARK with the parking brake engaged and disconnecting the negative battery cable. Then, label and unplug all transmission electrical connectors and remove any related brackets. Disconnect the shift cable from the shift lever at the transmission and remove the shift cable bracket from the rear powertrain mount. Disconnect the Output/Input Shaft Speed sensor and loosen the front wheel lug nuts and driveaxle/hub nuts. Remove the intake air duct and raise the vehicle, supporting it securely on jackstands. Drain the transmission fluid and remove both driveaxles. Remove the transmission oil cooler line assembly and support the engine from above using an engine hoist or support fixture. Remove the upper engine-to-transmission bolts and studs, disconnect the ABS wheel speed sensor at each front wheel, and remove the subframe. Support the transmission with a transmission jack and remove the bolts from the transmission-to-engine brace. Remove the starter and flywheel cover, and mark the relationship of the torque converter to the driveplate. Push the torque converter into the bell housing and remove the lower transmission-to-engine bolts. Mark the position of the driver's side powertrain mount bolts and remove them, along with the mount-to-transmission bolts and through-bolts on the front and rear mounts. Finally, ensure all wires, hoses, brackets, and mounts are disconnected and slide the transmission jack toward the side of the vehicle until the transmission is clear of the engine locating dowels, keeping it level throughout. To install the transmission assembly, follow the reverse of the removal procedure, ensuring the torque converter is properly engaged with the transmission and aligning the match marks on the torque converter and driveplate. Install all driveplate-to-torque converter bolts before tightening them, and tighten the transmission mounting bolts, driveaxle/hub nuts, and wheel lug nuts to the specified torque. Fill the transmission with the correct type and amount of automatic transmission fluid and shift the transmission into all gear positions to confirm shift cable adjustment, readjusting if necessary.

Genuine Chevrolet Cobalt Transmission Assembly

Trans Assembly

Select Vehicle by Model
Select Vehicle by VIN

Select Vehicle by Model

Make

Model

Year

Select Vehicle by VIN

For the most accurate results, select vehicle by your VIN (Vehicle Identification Number).

13 Transmission Assemblies found

View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17044110
$2498.42 MSRP: $2809.64
You Save: $311.22 (12%)
Ships in 1-3 Business Days
ADD TO CART
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Replaces: 17803828
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.4L
View related parts
Chevrolet Cobalt Transaxle Assembly, Man (4.05 Ratio)
Part Number: 55563239
Product Specifications
- Other Name: TRANSAXLE, Manual(5 Speed); Transaxle
- Replaces: 55560938
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005-2007 Chevrolet Cobalt | LEVEL 4 PERFORMANCE (SS) 2 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR | 4 Cyl 2.0L
View related parts
Chevrolet Cobalt Transaxle Assembly, Man (4.05 Ratio)
Part Number: 55560937
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005-2007 Chevrolet Cobalt | LEVEL 4 PERFORMANCE (SS) 2 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR | 4 Cyl 2.0L
View related parts
Chevrolet Cobalt Transaxle Asm,Man (3.82 Ratio) (Remanufacture)
Part Number: 19330521
Product Specifications
- Other Name: TRANSAXLE ASM,MAN (3.82 RATIO) (REMAN); Transaxle
- Replaces: 55564935
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008-2010 Chevrolet Cobalt | LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 4 DOOR | 4 Cyl 2.0L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 24235552
Product Specifications
- Other Name: TRANS REM
- Replaces: 24230065
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17803751
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2006 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.2L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17803904
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.2L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17804106
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Replaces: 17803955
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2009-2010 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 4 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.2L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)(Remanufacture)
Part Number: 17803749
Product Specifications
- Other Name: TRANSAXLE, Manual(5 Speed); Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2006 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.4L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17803902
Product Specifications
- Other Name: TRANSAXLE, Manual(5 Speed); Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2007 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.4L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 17804112
Product Specifications
- Other Name: TRANSAXLE, Manual(5 Speed); Transaxle
- Replaces: 17803980, 17803829
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL THREE (SS) 2 DOOR, LEVEL THREE (SS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.2L
View related parts
Chevrolet Cobalt Transaxle,Auto (Service)
Part Number: 24235553
Product Specifications
- Other Name: TRANSAXLE, Automatic; Transaxle
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2005 Chevrolet Cobalt | 2 DOOR, 4 DOOR, LEVEL 4 PERFORMANCE (SS) 2 DOOR, LEVEL ONE (LS) 2 DOOR, LEVEL ONE (LS) 4 DOOR, LEVEL TWO (LT) 2 DOOR, LEVEL TWO (LT) 4 DOOR | 4 Cyl 2.2L
View related parts
Chevrolet Cobalt Transaxle Asm,Man (3.82 Ratio) (Remanufacture)
Part Number: 19330522
Product Specifications
- Other Name: TRANSAXLE, Manual(5 Speed); Transaxle
- Replaces: 17804603, 55564936
- Warranty: This genuine part is guaranteed by GM's factory warranty.
Fits the following Vehicles:
- 2008-2010 Chevrolet Cobalt | LEVEL 4 PERFORMANCE/SC (SS) 2 DOOR, LEVEL 4 PERFORMANCE/SC (SS) 4 DOOR | 4 Cyl 2.0L

Chevrolet Cobalt Transmission Assembly

Each OEM Chevrolet Cobalt Transmission Assembly we offer is competitively priced and comes with the assurance of the manufacturer's warranty for the part. Furthermore, we guarantee the speedy delivery of your orders right to your doorstep. Our hassle-free return policy is also in place for your peace of mind.

Chevrolet Cobalt Transmission Assembly Parts Questions & Experts Answers

Transaxle,Auto (Service)
17044110
Q: What is the importance of determining the nature of a problem with the automatic transaxle before considering repair work on Chevrolet Cobalt,HHR and Saturn ION?
A: In the event of a problem with the transmission assembly, determine the cause before considering repairs. This requires knowledge of the transmission assembly's operation and access to specialized test equipment. Due to the complexity of diagnosis and repair, this manual does not cover these procedures, therefore refer problems to a qualified repair facility.
Transaxle,Auto (Service)
17044110
Q: How do you remove the transaxle for Chevrolet Cobalt,HHR,Pontiac G5 and Saturn ION?
A: To remove the transmission assembly, start by placing the vehicle in PARK with the parking brake engaged and disconnecting the negative battery cable. Then, label and unplug all transmission electrical connectors and remove any related brackets. Disconnect the Shift Cable from the shift lever at the transmission and remove the shift cable bracket from the rear powertrain mount. Disconnect the Output/Input Shaft Speed sensor and loosen the front wheel lug nuts and driveaxle/hub nuts. Remove the intake air duct and raise the vehicle, supporting it securely on jackstands. Drain the transmission fluid and remove both driveaxles. Remove the transmission oil cooler line assembly and support the engine from above using an engine hoist or support fixture. Remove the upper engine-to-transmission bolts and studs, disconnect the ABS wheel speed sensor at each front wheel, and remove the subframe. Support the transmission with a transmission jack and remove the bolts from the transmission-to-engine brace. Remove the starter and flywheel cover, and mark the relationship of the torque converter to the driveplate. Push the torque converter into the bell housing and remove the lower transmission-to-engine bolts. Mark the position of the driver's side powertrain mount bolts and remove them, along with the mount-to-transmission bolts and through-bolts on the front and rear mounts. Finally, ensure all wires, hoses, brackets, and mounts are disconnected and slide the transmission jack toward the side of the vehicle until the transmission is clear of the engine locating dowels, keeping it level throughout. To install the transmission assembly, follow the reverse of the removal procedure, ensuring the torque converter is properly engaged with the transmission and aligning the match marks on the torque converter and driveplate. Install all driveplate-to-torque converter bolts before tightening them, and tighten the transmission mounting bolts, driveaxle/hub nuts, and wheel lug nuts to the specified torque. Fill the transmission with the correct type and amount of automatic transmission fluid and shift the transmission into all gear positions to confirm shift cable adjustment, readjusting if necessary.

Related Chevrolet Cobalt Parts

Browse by Year

2010 Transmission Assembly 2009 Transmission Assembly 2008 Transmission Assembly 2007 Transmission Assembly 2006 Transmission Assembly 2005 Transmission Assembly